Frequent question: Can a motorcycle run with a bad stator?

Can you start a motorcycle without a stator?

If the stator is bad, the bike won’t run at all. The stator generates energy for spark. Assuming the air cleaner is clean and other general maintenance has been performed, if the bike won’t kick start but runs as you state, the problem is probably either the spark plug and/or fuel delivery.

What makes a stator go bad on motorcycle?

To answer why stators fail, it is because the coating on the windings breaks down, usually because of heat, causing a short which can also burn the fine wire of the winding in two at the short causing an open circuit. The way to prevent failures is to prevent the heat.

How do you check for a bad stator?

Insert each probe into a stator socket. You should read around 0.2 to 0.5 ohms. If you show an open circuit with the “Open” or infinity reading or have higher resistance, then the stator is bad and you must replace it. If these tests all produce positive results, then the stator itself is good.

How many volts should a motorcycle stator put out?

For example a 32-amp stator should put out 18 volts AC (VAC) per each 1000-RPM. At 2000 it should be 36 VAC (18×2). At 3000 RPM it should be 54 VAC (18 X 3).

IT IS IMPORTANT:  Do I need a motorcycle license in Washington state?

Can you fix a bad stator?

How to Fix a Bad ATV Stator. If your ATV’s stator is bad and you aren’t a master at working with electrical components on vehicles, then you’ll have to replace the entire stator. Stators aren’t usually expensive for most ATVs. They will usually cost under $100 for the part and can be significantly less.

What causes stator failure?

When a stator fails, it is largely due to the degradation or aging of its insulation through external occurrences and materials being introduced into its system.

Can a bad stator cause bogging?

yes, A stator thats breaking down will work good when cold but fail are act up as soon as it warms up, The symptoms you mentioned sound like it could be a stator.

Can a stator go bad from sitting?

Stators do not go bad from sitting unless the mag housing is full of water.

How hard is it to replace a stator?

Replacing the stator is not too complicated and requires a socket set and some heat resistant gasket repair silicone only. … On 2006-07 Honda Fireblades the stator is located on the left hand side behind the crash protector.

How much does it cost to fix a stator?

Stator & Rotor

A new stator and rotor set typically costs between $250 and $1,500. They are stationary and rotating parts of any system that generates electricity. When they stop working seamlessly, they need repair or replacement.